·设为首页 ·加入收藏 ·给我留言

混凝土外加剂系统

保温装饰材料系统

道路修补材料系统

防水防腐材料系统

混泥土砂浆

隧道桥梁防水系统

隧道桥梁加固系统

【曾道人免费资料】高速桥梁系统系统

灌浆加固材料系统

您当前的位置: 首页 > 产品展示 > 灌浆加固材料系统 > 正文
CGM高强无收缩灌浆料

本品分为三种
 
?1?   快硬高强微膨胀加固型
 
?2?   早强快硬豆砂型
 
?3?   普通早强超细型.
 
产品介绍
 
CGM-2001型百强牌高强无收缩灌浆料与传统的细石混凝土及环氧化砂浆相比,具有流动性更好、强度更高、耐老化、耐高温、高抗渗、防蜕变、无收缩、膨胀性好、施工易于控制、简便快捷等特点。其1天强度大于20MPa,3天强度大于30Mpa设备安装后72小时可试机运转,28天强度达到60-80MPa,本品均达到灌浆材料行业标准及国家标准。
 
   CGM-2002型高强无收缩灌浆料具有半天强度更高的特点, 1天强度可达30Mpa,主要用于快速抢修或更换设备的基础灌浆,创造极大的经济效益。GM-2002型具有超强、高强等特点, 1-2天设备安装完毕后可运行生产。自流态大,现场只需加水搅拌后即可进行施工,不需振捣便可充填全部间隙。微膨胀:以保证灌浆料与基础紧密接触。耐久性200万次疲劳实验,50次冻融循环试验,强度无明显变化。抗油渗:在机油中浸泡30天后其强度比浸油前提高10%以上。 
 
适用范围与施工技术方法:
 
 一、钢骨结构基础接缝填充灌浆。2、机械设备地脚螺栓、锚栓基座的固定灌浆。3、桥梁基座,支撑垫混凝土面层,岩基灌浆。4、连续墙,逆打墙柱、地下室墙板,后打耐震壁。5、钢厂、电厂、机械厂等的快速修护灌浆。6、桥面、伸缩缝、路面、机场跑道快速养护修复。7、轨道板、预制水泥制品缺角及裂缝修复。
 
二、加水量一般应按随货提供的产品出厂合格证上的推荐用水量加入,一般为用水量的13-15%,该产品不需振捣、灌注施工完成后,终凝以后开始进行洒水养护.养护期4-7天。本品使用机械搅拌机械搅拌不低于3分钟、人工搅拌不少于4-5分钟,每2200 公斤高强无收缩灌浆料为1立方。
 
主要性能指标国家或企业及行业标准: GB/T50448-2008、CJ/T986-2005、YB/T9261-98。
 
 
 
 
 初 凝min
粒径(4.75mm方孔筛余)%
 流动度mm
   抗压强度Mpa
膨胀率%
沁水率%
钢筋握裹强度Mpa
1d
3d
28d
1d
圆钢28d
特级品
≥60
≤2.0
≥330
≥32
≥45
≥70
≥0.02
≤0
≥4.0
一级品
≥120
 
≥290
≥22
≥40
≥60
 
 
 
备 注
 
 
保 质 期;高强无收缩灌浆料有效期为120天,过期后必须经试验合格方可使用。
 
注意?~:1、本品严格控制加水量2本品严禁添加砂石料及外加剂。
 
  装; 采用双成塑料编织包装.净重:40-50KG。
 
This product is divided intothree
(1)fast hardening and high strengthmicro-expansivereinforcement type
(2)early strength fasthard beansand
(3)ultrafinecommonearly strong.
Product introduction
A,CGM-2001 typetopbrand of high-strengthfine stone concreteand epoxidation ofmortarnoshrinkage grouting materialas compared with the traditional,withbetter fluidity,high strength,aging resistance,high temperature resistance,high permeability,preventingdecay,no shrinkage,expansibility,easycontrol,convenientconstructionetc..The1 days strengthgreater than 20MPa,3 days strengthgreater than 30Mpaequipment installedafter 72 hours cantry machineoperation,28 daysstrength reaches 60-80MPa,the productreaches thegrouting materialindustry standards andnational standards.
Two,the CGM-2002high strength non-shrinkage grouting materialhas the characteristics ofhighstrength,1 days strengthup to 60Mpa,mainly used forfoundationgroutingrepair or replacement equipment,create great economicbenefit.CGM-2002has superstrength,etc.,1-2 daysafter the installation of equipmentcan run production.Since theflowis large,the scene onlyafter mixing with waterconstructioncan be carried out,withoutofnon-vibratingcan fillallspace.Micro expansion:to ensure grouting materials andbasic close contact.Durability of 2000000times fatigue experiments,50 times freeze-thawcycle test,strengthhas no obvious change.Oil resistantinfiltration:soak 30 days in oiland its strengthis 10% higher than thatbeforeimmersion.
Scope of applicationandconstruction technique:
One,basicsteel structurejointgrouting.Fixedfilling 2,mechanical equipment,anchor bolt,anchor bolt.3,the bridgebase,supportingcushion of concretesurface layer,rockgrouting.4,the continuous wall,the smallwall column,the basement wall,after playing theseismicwall.Quick repairfilling 5,steel mills,power plant,machinery plant.6,expansion joints,pavement,bridge,airport runwayquick maintenancerepair.7,track slab,precastcement productdefectsandrepair of cracks.
Two,the amount of watershould bein accordance withthe productfactorycertification recommended wateradded,usuallywithwater at 13-15%,the product does notneed to vibration,perfusionafter the completion of construction,final set laterbegincuringcuring period of4-7 days.This product isthe use ofmechanicalmixing machinemixingof not less than 3minutes,artificialmixing of not less than4-5 minutes,every 2200 kilograms ofhigh-strength non-shrinkage grouting materialwas 1 cubic.
The mainperformance index of the nationalor enterpriseand industry standards:GB/T50448-2008,CJ/T986-2005,YB/T9261-98.
The initial settingof Min particle size(4.75mmsquare holeShaiyu)%fluidity mmcompressive strength of Mpaexpansion%Qinshui%gripstrength Mpa
1D3D28d1Dsteel28d
Super≥ 40requirements:1days startinitialflow≥ 300≥ 40≥60 ≥80 ≥0.02 ≤0 ≥4
Agrade≥ 120first-run≥ 290≥20 ≥40 ≥60 ≥0.02 ≤0
Notethe ratio of material to water:1:0.135-0.145
Quality guarantee period;high-strength non-shrink grouting materialis valid for a period of120 daysafter the expiration,must beused by thetest.
Note- items:1,thestrict control ofwater,2,the product is prohibitedto addaggregateand admixtures.
Packages;doubleplasticwoven packagingnet weight:40-50KG.
 

↓下一篇:环氧修补砂浆

COPYRIGHT © 2013 任我发官方心水主论坛 版权所有 技术支持: 备案中
地址:昆明市官渡区关上南路98号 电话:0871-67495611 传真:0871-67495611 联系人:袁进先 手机:13700652789 E-mail:657084233@qq.com
友情链接: